Dose Escalation Trial of Intrasite Vancomycin Pharmacokinetics

Despite extremely close attention to aseptic technique and the use of prophylactic IV antibiotics, wound infection rates for posterior instrumented spinal surgery have been as high as \~20% in published studies\[4-13\]. Such infections can be devastating for patients, frequently requiring multiple re-operations to remove and then replace spinal implants, lengthy hospital stays, prolonged courses of intravenous antibiotics, pain, immobility, and increased risk of other complications. While the cost of the initial surgical episode can be upwards of $250,000, the total cost of care can increase to more than quadruple this number when complications like wound infection occur\[14, 15\]. Given the impetus to decrease healthcare costs and a federal reimbursement policy denying payment for any care surrounding a wound infection, it is critical to search for cost-effective ways of preventing surgical wound infections\[14, 16\]. For several decades the standard of care in North America for surgical wound infection prophylaxis has been IV cephalosporin administration within one hour of incision, followed by interval IV dosing for 24 to 48hrs post-procedure\[5, 13\]. In some settings these antibiotics now effectively treat less than half of identified infection-causing organisms\[17, 18\]. In response, some groups of surgeons, including at the investigators' own institution, have begun placing lyophilized Vancomycin into the surgical wound bed at the conclusion of the procedure in an effort to further reduce wound infection rates\[1-3\]. The rationale behind this intrasite antibiotic application is to increase local concentrations of antibiotic to many times the minimally inhibitory concentration (MIC) for even moderately-resistant gram-positive organisms, thereby increasing the bacterial kill rate\[3\]. It is also thought that local antibiotic application should minimize blood concentrations of the drug, thereby minimizing systemic complications like renal toxicity. Additionally, it is hypothesized that intrasite antibiotic therapy could be less inclined to generate resistant organisms due to a steep concentration gradient from the wound to the systemic circulation. The site of potential infection (the wound) receives a dose of antibiotic vastly exceeding the saturation concentration for bactericidal effect while the systemic concentration remains extremely low. Bacteria should therefore be completely exterminated in the area of the wound or elsewhere exposed to such a minimal concentration of Vancomycin that selection for resistant organisms is avoided. While none of these hypotheses have been rigorously or prospectively tested, three retrospective studies have recently published a total of 2,479 spinal fusion patients treated with intrasite Vancomycin for wound infection prophylaxis\[1-3\]. The largest of these studies demonstrated a 0.99% infection rate in the treatment group, among the lowest rates ever published\[1\]. Two of the studies showed large and statistically significant decreases in the wound infection rate, compared to historical controls, when using intrasite Vancomycin in addition to standard of care IV cephalosporins. Preliminary evidence in one study also indicated high levels of Vancomycin within the wound and low or undetectable levels within the blood following surgery\[3\]. All of these studies specifically cited that no adverse events had been observed related to the treatment\[1-3\]. If intrasite Vancomycin proves to be safe and effective for preventing spinal fusion surgical site infections, the treatment will offer great clinical value both for reducing morbidity and also for decreasing large unsupported costs. A future large prospective efficacy trial would be required to provide high-level evidence for this new mode of antibiotic therapy in order to justify wide-spread adoption of the practice in spine surgery. Such data in any population might also be generalizable to surgical wounds at large and prompt a paradigm shift in infection prophylaxis for all types of surgical wounds. The proposed study addresses necessary prerequisites for such a large-scale efficacy trial, including basic pharmacokinetic and preliminary prospective safety data.